Active Autowerke 1,000 HP E46 M3 Turbo Project Complete - M3 Forum 2010 2009 BMW M3 2008 BMW M3 BMW E90 M3 E92

Omar@ActiveAutowerke · 04-30-2007, 03:22 PM

Sorry Mods, not sure if this is the right section. Please move if necessary. Just wanted to share with the members.

Over the past a couple of months we have been working on a E46 M3 Turbo Project. We were able to finish up the car last week and have it shipped over to Los Angeles for Bimmerfest.

We did a complete build from bottom up and we exceeded our goals.

The owner of the car is one of our board members Vik a.k.a TazaM3.

I want to first of thank everyone who helped in the project and a special thanks to a couple of our staff members who worked in overdrive to make this happen, Barry Elton ( Special Thanks ) , Lance Ho Lung, and Yirot.

The car made 836-838 RWHP in 92 Degree plus weather!!!

Here is a list of the mods followed by pictures and a video. Enjoy. See you all at Bimmerfest 2007.

Active Autowerke / Vik a.k.a TazaM3 1,000 HP Turbo E46 M3
Custom Innovative 74mm Dual Ball Bearing Turbo built for Active Autowerke
Active Autowerke Turbo Spec Intake Manifold
Active Autowerke Turbo Exhaust Manifold
Active Autowerke Custom AEM Plug and Play ECU
Active Autowerke Custom 3.5" Stainless Steel Exhaust System w/ Electronic Cutout
Active Autowerke Custom Fuel Rail
Custom 4" Turbo Intercooler ( Active Autowerke Spec )
Custom 4" Polished Intercooler Piping by Active Autowerke
Custom Active Autowerke Spec Tilton Clutch and Flywheel
Active Autowerke 1000 CC Injectors
Active Autowerke Custom 1200HP Fuel Pump System
Active Autowerke Built Engine
CP Pistons ( Active Autowerke Spec )
Pauter Rods ( Active Autowerke Spec )
BMW Motorsport Bearings ( Active Autowerke Spec )
Custom Turbo Headgasket ( Active Autowerke Spec )
ARP Headstuds ( Active Autowerke Spec )
Active Autowerke Custom Studs for Main Caps
Custom Active Autowerke Coil Packs
Custom AEM CDI
Two Tial 50MM BOV's
Tial 44mm Wastegate
Greddy Profec B Boost Controller]
AEM Uego
Brembo Gran Turismo Mono Block Brakes ( 1st to have them in the Country )
Defi Gauges
CROSS Coilover Suspension
Porsche GT3 Carbon Fiber Seats
Carbon Fiber Door Panels Custom Made
Rear Seat Delete

Pictures of the Entire Build Below:

Omar@ActiveAutowerke · 04-30-2007, 03:23 PM

Hello here are some pictures of the dyno charts and a video.

Pump Gas Dyno Sheet (100 Octane):

Pump Gas Dyno Conditions:

Race Gas Dyno Sheet:

Race Gas Dyno Conditions:

Video of the Active Autowerke 1,000 HP E46 M3 Turbo Project

Now can we tune your 335?

j|rz44 · 04-30-2007, 03:25 PM

Nice!

E90Boy · 04-30-2007, 03:42 PM

That's one helluva car, but look at the turbo lag!!!

HyperM3 · 04-30-2007, 03:44 PM

Holy crap. No, litterally, I think I just did that.

335i-SG · 04-30-2007, 03:56 PM

Shake and Bake!

That Just happened! wow

e.n335 · 04-30-2007, 03:59 PM

Quote:

Originally Posted by Active Autowerke

Now can we tune your 335 ?

Please don't do this to my car !

Nobody said you couldn't tune the 335i. But this and the AA/XEde is a little different story.

BTW, the M3 seems to be a bit rough in idling

Congratulations !

Cheers
Eugen

Jean@ActiveAutowerke · 04-30-2007, 04:02 PM

Quote:

Originally Posted by 335i-SG

Shake and Bake!

That Just happened! wow

El diablo (stands for fighting chicken) and the magic man. LOL.

Jean@ActiveAutowerke · 04-30-2007, 04:05 PM

Quote:

Originally Posted by eugen.niederreiter

Please don't do this to my car !

Nobody said you couldn't tune the 335i. But this and the AA/XEde is a little different story.

BTW, the M3 seems to be a bit rough in idling

Congratulations !

Cheers
Eugen

We were just implying that we are more than capable of tuning any BMW especially one that came turbo from the factory.

This car is running a complete AEM Standalone ECU. We are the only company that has that for an E46 M3 right now. You cannot order that over the shelf.

Basically our tuners are a bit more advanced than "other".

p.s. Watch the video close.. the exhaust is loud but idle is rather smooth for 1,000 CC injectors and 1,000 HP.

jadeddjay · 04-30-2007, 04:10 PM

Quote:

Originally Posted by Active Autowerke

Now can we tune your 335?

sure, how much lol

e.n335 · 04-30-2007, 04:11 PM

Quote:

Originally Posted by Active Autowerke II

p.s. Watch the video close.. the exhaust is loud but idle is rather smooth for 1,000 CC injectors and 1,000 HP.

It's great what you did. I have owned the E46 M3 , I never expected that it is possible what you have done.

Again, great.

Cheers
Eugen

derryck · 04-30-2007, 04:22 PM

Gorgeous set up and great numbers but someone must have really wanted to lay claim to fastest M3 on the street as that's not a cheap set up. I would have just started with a better building block if I wanted to go that fast.

musc · 04-30-2007, 04:25 PM

you guys are insane, lol. Great work

Terry335 · 04-30-2007, 04:32 PM

Damn!!! Does that have "launch control"?

Omar@ActiveAutowerke · 04-30-2007, 04:47 PM

Quote:

Originally Posted by Terry335

Damn!!! Does that have "launch control"?

"that will be on our level 2 along with vanos control"............... That was classic.

All jokes aside, it does have launch control, vanos control, and anti- lag. It is a complete AEM standalone with all the goodies.

Jay@ATP · 04-30-2007, 04:50 PM

one question. your talking bout 1000 BHP, not WHP right???

WilyB · 04-30-2007, 04:51 PM

Wow, impressive. How long will the drivetrain last, or did you also upgrade the gearbox etc.?

Jean@ActiveAutowerke · 04-30-2007, 04:54 PM

Quote:

Originally Posted by Active Autowerke

"that will be on our level 2 along with vanos control"............... That was classic.

All jokes aside, it does have launch control, vanos control, and anti- lag. It is a complete AEM standalone with all the goodies.

..with a custom harness so it is used as a piggy back technically. All factory controls still work.

DanMardik · 04-30-2007, 04:55 PM

nuts.

spacedogg · 04-30-2007, 04:56 PM

Quote:

Originally Posted by 335i-SG

Shake and Bake!

That Just happened! wow

Good job guys...that looks awesome!

pauly1 · 04-30-2007, 05:09 PM

Very impressive #'s!

However, we've all the heard the expression "you can never have enough power." I think in this case, that might not hold true. At the track with slicks, the car will be insanse. But on the street, I think the car is pretty much useless under 80 mph. Even then I think you'll have problems.

Sick car regardless.

E(@M# · 04-30-2007, 05:14 PM

those numbers are ridiculous

04-30-2007, 03:22 PM	#1
Omar@ActiveAutowerke BimmerPost Supporting Vendor Drives: E92 M3 Join Date: Feb 2007 Location: Miami Posts: 1,050 iTrader: (0)	Active Autowerke 1,000 HP E46 M3 Turbo Project Complete Sorry Mods, not sure if this is the right section. Please move if necessary. Just wanted to share with the members. Over the past a couple of months we have been working on a E46 M3 Turbo Project. We were able to finish up the car last week and have it shipped over to Los Angeles for Bimmerfest. We did a complete build from bottom up and we exceeded our goals. The owner of the car is one of our board members Vik a.k.a TazaM3. I want to first of thank everyone who helped in the project and a special thanks to a couple of our staff members who worked in overdrive to make this happen, Barry Elton ( Special Thanks ) , Lance Ho Lung, and Yirot. The car made 836-838 RWHP in 92 Degree plus weather!!! Here is a list of the mods followed by pictures and a video. Enjoy. See you all at Bimmerfest 2007. Active Autowerke / Vik a.k.a TazaM3 1,000 HP Turbo E46 M3 Custom Innovative 74mm Dual Ball Bearing Turbo built for Active Autowerke Active Autowerke Turbo Spec Intake Manifold Active Autowerke Turbo Exhaust Manifold Active Autowerke Custom AEM Plug and Play ECU Active Autowerke Custom 3.5" Stainless Steel Exhaust System w/ Electronic Cutout Active Autowerke Custom Fuel Rail Custom 4" Turbo Intercooler ( Active Autowerke Spec ) Custom 4" Polished Intercooler Piping by Active Autowerke Custom Active Autowerke Spec Tilton Clutch and Flywheel Active Autowerke 1000 CC Injectors Active Autowerke Custom 1200HP Fuel Pump System Active Autowerke Built Engine CP Pistons ( Active Autowerke Spec ) Pauter Rods ( Active Autowerke Spec ) BMW Motorsport Bearings ( Active Autowerke Spec ) Custom Turbo Headgasket ( Active Autowerke Spec ) ARP Headstuds ( Active Autowerke Spec ) Active Autowerke Custom Studs for Main Caps Custom Active Autowerke Coil Packs Custom AEM CDI Two Tial 50MM BOV's Tial 44mm Wastegate Greddy Profec B Boost Controller] AEM Uego Brembo Gran Turismo Mono Block Brakes ( 1st to have them in the Country ) Defi Gauges CROSS Coilover Suspension Porsche GT3 Carbon Fiber Seats Carbon Fiber Door Panels Custom Made Rear Seat Delete Pictures of the Entire Build Below: __________________ Omar Murray Director of Sales

04-30-2007, 03:23 PM	#2
Omar@ActiveAutowerke BimmerPost Supporting Vendor Drives: E92 M3 Join Date: Feb 2007 Location: Miami Posts: 1,050 iTrader: (0)	Hello here are some pictures of the dyno charts and a video. Pump Gas Dyno Sheet (100 Octane): Pump Gas Dyno Conditions: Race Gas Dyno Sheet: Race Gas Dyno Conditions: Video of the Active Autowerke 1,000 HP E46 M3 Turbo Project Now can we tune your 335? __________________ Omar Murray Director of Sales

04-30-2007, 03:25 PM	#3
j\|rz44 Lieutenant Colonel Drives: 335i\|E92 Join Date: Oct 2006 Location: Lost Posts: 1,683 iTrader: (2) View j\|rz44's Garage	Nice! __________________ Life is Good

04-30-2007, 03:44 PM	#5
HyperM3 Too many Alex's, from now on, call me Beaufort Drives: See Sig Join Date: Feb 2007 Location: Lawrenceville, NJ Posts: 6,106 iTrader: (8)	Holy crap. No, litterally, I think I just did that. __________________ Doing mods for the tri-state area; Fender Rolling, CDV Mod, LUX install, Short-shift kits, V1-Hardwire and more! PM for details

04-30-2007, 04:25 PM	#13
musc Banned Drives: numerous Join Date: Dec 2006 Location: SC Posts: 1,154 iTrader: (0) View musc's Garage	you guys are insane, lol. Great work __________________ *2005* E46 ///M3 \| Alpine White \| Cinnamon \| Aluminum \| Premium \| SMG-II \| Bi-Xeon \| HK \| CSL Wheels \| OEM CSL Headers \| 12.88 @ 108 *2008* C63 AMG \| Black \| Black \| Black Maple \| AMG Seating \| P2: Premium II \| Multimedia \| iPod \| 12.38 @ 115.8 *2009* Camry SE-V6 \| Classic Silver \| Charcoal \|14.44 @ 100

04-30-2007, 03:42 PM	#4
E90Boy Captain Drives: 06 E90 325i Join Date: Aug 2005 Location: Boston Posts: 634 iTrader: (4) View E90Boy's Garage	That's one helluva car, but look at the turbo lag!!!

04-30-2007, 03:56 PM	#6
335i-SG Private First Class Drives: 2007 335i Sedan Join Date: Apr 2007 Location: Miami,FL. Posts: 176 iTrader: (0)	Shake and Bake! That Just happened! wow

04-30-2007, 04:22 PM	#12
derryck Second Lieutenant Drives: 2007 335i Join Date: Apr 2007 Location: Florida Posts: 296 iTrader: (0)	Gorgeous set up and great numbers but someone must have really wanted to lay claim to fastest M3 on the street as that's not a cheap set up. I would have just started with a better building block if I wanted to go that fast.

04-30-2007, 04:32 PM	#14
Terry335 Banned Drives: 335i Join Date: Jan 2007 Location: Socal Posts: 2,588 iTrader: (0)	Damn!!! Does that have "launch control"?

04-30-2007, 04:50 PM	#16
Jay@ATP Private First Class Drives: 02 S2k, 06 EVO IX Join Date: Dec 2006 Location: Chico, CA Posts: 79 iTrader: (0)	one question. your talking bout 1000 BHP, not WHP right??? __________________ ADVANCED TOUGE PERFORMANCE

04-30-2007, 04:51 PM	#17
WilyB Captain Drives: E92 335 Join Date: Jan 2007 Location: USA Posts: 672 iTrader: (0) View WilyB's Garage	Wow, impressive. How long will the drivetrain last, or did you also upgrade the gearbox etc.?

04-30-2007, 04:55 PM	#19
DanMardik Captain Drives: 08 INFINITI G37S Join Date: Dec 2006 Location: Irvine, CA Posts: 737 iTrader: (0)	nuts. __________________ *RIP 2007 335i Sedan*

04-30-2007, 05:09 PM	#21
pauly1 Private Drives: Nikes Join Date: Jul 2005 Location: ny Posts: 45 iTrader: (0)	Very impressive #'s! However, we've all the heard the expression "you can never have enough power." I think in this case, that might not hold true. At the track with slicks, the car will be insanse. But on the street, I think the car is pretty much useless under 80 mph. Even then I think you'll have problems. Sick car regardless. Last edited by pauly1; 04-30-2007 at 08:14 PM.

04-30-2007, 05:14 PM	#22
E(@M# Private First Class Drives: 94' corolla Join Date: Mar 2007 Location: FL Posts: 190 iTrader: (0)	those numbers are ridiculous