|
|
06-25-2014, 05:16 PM | #1 |
Major
112
Rep 1,260
Posts |
Oil Cap Leak
Hi all,
i've had a bit of a oil leak for the last 4 months but it has gotten worst. In 2 days, my gauge went from full to half. I'm planning on going by the dealer tomorrow for a replacement. Can someone please post the Service Bulletin for the oil cap? ...or tell me where i can find it. My cover is looking like crap with the paint bubbling and coming off. It looks like the inner wall inside the cover is also peeling off. Should I be worried about the debris inside??
__________________
Last edited by Flea7; 06-25-2014 at 11:25 PM.. |
06-25-2014, 06:34 PM | #2 |
Banned
101
Rep 701
Posts |
You’ve known for 4 months and did nothing? Why?
Doesn’t look too good imo. Here is a healthy one. http://www.m3post.com/forums/showthr...=503893&page=2 This is the part # for the new one..maybe someone can confirm 11 12 8 507 153 |
Appreciate
0
|
06-25-2014, 06:40 PM | #3 |
Major
112
Rep 1,260
Posts |
It wasn't too bad of a problem before....most of the time it would hold and not leak.
I know the part number and i know what a healthy one looks like.....does anyone have the SB on this so I can show the dealer if they give me a hard time on the replacement.
__________________
|
Appreciate
0
|
06-26-2014, 08:10 AM | #6 |
Stop the hate, get a V8
3848
Rep 8,625
Posts |
Peeling is not a big deal, I've seen that on countless cars over the years.
__________________
Now: 2017 Corvette Grand Sport, 2021 AMG C63 S sedan
Past: 2011.5 M3 sedan ZCP |
Appreciate
0
|
06-26-2014, 11:30 AM | #7 |
Brigadier General
513
Rep 3,482
Posts |
Mine just started doing this, so I'm gonna have to get my dealer to replace it. Although, my leak is nowhere near as bad as yours. Hope it all works out, OP.
__________________
2011 e90 M3 Space Grey DCT ZCP- eAs, BMW Performance, Agency Power, Macht Schnell, iND, Milltek, Volk, Challenge, Stoptech, Ohlins
BMWCCA:518970 |
Appreciate
0
|
06-26-2014, 12:15 PM | #8 | ||
General
62743
Rep 24,513
Posts |
Quote:
Quote:
__________________
"MAX VERSTAPPEN" IS THE 2021+2022+2023 F1 WORLD CHAMPION - #UnLeashTheLion
BPM DEV-Tune & DCT Software-Tune & Servotronic & coding ///Alpine HID Angeleyes ///Oem.exhaust mod. |
||
Appreciate
0
|
06-26-2014, 01:19 PM | #9 | |
Brigadier General
513
Rep 3,482
Posts |
Quote:
__________________
2011 e90 M3 Space Grey DCT ZCP- eAs, BMW Performance, Agency Power, Macht Schnell, iND, Milltek, Volk, Challenge, Stoptech, Ohlins
BMWCCA:518970 |
|
Appreciate
0
|
06-26-2014, 01:51 PM | #10 |
General
62743
Rep 24,513
Posts |
__________________
"MAX VERSTAPPEN" IS THE 2021+2022+2023 F1 WORLD CHAMPION - #UnLeashTheLion
BPM DEV-Tune & DCT Software-Tune & Servotronic & coding ///Alpine HID Angeleyes ///Oem.exhaust mod. |
Appreciate
0
|
06-26-2014, 02:45 PM | #11 |
Major
112
Rep 1,260
Posts |
Thanks for all the feedback and help guys!
It looks like the new cap is also prone to leaking as well. For now, I bent the arms down on the cap until I find the rubber gasket material thick enough to seal it tight. I really don't like going to the dealer for anything ...so i'll probably fix this myself. As for the peeling,.....I don't think the dealer is going to make any effort to correct it. I don't know why BMW painted the inside of the cover? To insulate it from the heat? They had to know that it was going to peel eventually. I think I will DIY a cover painting project next time i change my plugs.
__________________
|
Appreciate
0
|
06-26-2014, 04:24 PM | #12 |
Brigadier General
708
Rep 3,948
Posts |
You can replace the oil filler cap until the cows come home. Until you fix that chip on the oil filler neck on the valve cover it will continue to leak. I had this happen on my 2011 M3. Took the car to the dealer for its oil change, after that I started getting seepage. Took it back to the dealer they replaced the oil filler cap, still leaked. I changed out to a new valve cover and the leak was gone.
Dave
__________________
2020 Ford Mustang GT 6MT PP1 444rwhp
(Sold)2013 M3 Coupe-MR/BLK ZCP, 2011 M3 Coupe-MR/Blk 2007 Porsche 997C2S Speed Yellow/Blk sport seats 2004 BMW M3 Imola/Blk |
Appreciate
0
|
06-27-2014, 01:26 PM | #13 |
Bad Lieutenant
232
Rep 3,517
Posts |
I've never seen this peeling paint issue in my area. Could there be a correlation with the area you live? Salt air? Extreme heat?
__________________
02 E39M5 | TiAg/Schwartz | Tubi Rumore | Ultimate Ti Pedals | E60 SSK | Jim Blanton 3.45 40/100% | Coby Alcantara | StrongStrut STB
|
Appreciate
0
|
06-27-2014, 07:52 PM | #14 |
Major
112
Rep 1,260
Posts |
Update:
Well, I went to BMW Seattle and they didn't give me a new cap. Even with a SB they claim that it wasn't free. They knew nothing about the paint peeling off inside the cover and didn't see to alarmed about it. Basically, I knew more than them. LOL...I even know the parts manager and GM too! Good news is the leak stopped by bending down the tabs on my existing cap for now. I didn't have any leaking today. Also, I got to test drive the new M4 ....hhhhmmmmmm
__________________
|
Appreciate
0
|
10-30-2014, 09:30 AM | #15 |
Registered
0
Rep 1
Posts |
Flea7, i have the exact same problem with pain peeling off the oil cap seal resulting in uneven sealing..but mine is a result of mechanic's poor workmenship when replacing my plug and coil, using my engine valve cover as leverage , causing the crack/ peel
Shit happens, well, will try bending the Tab to have a tighter seal. thx for sharing |
Appreciate
0
|
Post Reply |
Bookmarks |
Thread Tools | Search this Thread |
|
|