BMW M3 Forum (E90 E92)

BMW Garage BMW Meets Register Search Today's Posts Mark Forums Read

Go Back   M3Post - BMW M3 Forum > M3 (E90 / E92 / E93) > General M3 Forum (E90 + E92 + E93)
Post Reply
Thread Tools Search this Thread
      03-09-2010, 04:45 PM   #1

Jason's Avatar
Drives: E90 M3
Join Date: Mar 2005
Location: USA

Posts: 16,623
iTrader: (0)

Cool a-workx M3 proves that balance beats power on the track (great article!)

From bimmer-mag:

Simply Well Balanced
With well-executed but modest modifications, the a-worxk M3 wins its class at the 2009 Tuner Grand Prix, proving that a well-balanced car will beat a more powerful one every time.

By Ian Kuah
Photography by Ian Kuah

To make a car quicker from A to B, you don’t need more horsepower. Better handling and braking alone can do the trick, though it helps if the car also becomes more user-friendly and confidence-inspiring at the limit.

Better handling does not always mean stiffer, however, especially on public roads that fall short of Germany’s billiard table smooth tarmac. Here, a good secondary ride is needed to filter out the short, sharp bumps that can upset a powerful car mid-corner, just as it’s trying to deploy its horses for the exit.

And for track day use, a car’s suspension geometry is just as important as its shocks and springs, but geometry adjustments are rarely possible on unmodified road cars. Even the E92 M3, which is as close to a street/track car as BMW makes, doesn’t allow for the kind of front camber adjustment required to make full use of sticky R-compound tires.

Most M3 drivers will likely never notice the absence of such adjustments. But if you want to get the most out of the car on the street or at track days—or if you want to win your class at the Sport Auto magazine Tuner Grand Prix held every year at Hockenheim—you’ll need to figure out a way to work around it. And that’s exactly what German tuner a-workx did before entering its M3 in the Tuner GP’s Saloon Class for normally aspirated, street-legal cars.

Despite being only lightly modified compared to its direct competitors, the a-workx M3 managed to take the Saloon Class win ahead of cars like the C63 AMGs entered by Väth and Lorinser. To do so, a-workx honed the M3’s handling and grip to make full use of its available power, a formula that proved ideal on the relatively short and twisty Club Circuit at Hockenheim.

From Ferrari Challenge to Tuner GP

Based in Munich, a-workx is the brainchild of entrepreneur Franz Wieth, a hard-core enthusiast who in the early 1990s entered a 348 GTB in the German Ferrari Challenge. In 1999, he founded Wieth Racing to prepare road and race cars for customers, and in 2003 that company was taken over by his son, Niko. In 2006, Niko founded a-workx to address road car tuning activities, incorporating Wieth Racing into the new operation as its motorsport division.

Today, a-workx prepares cars for its own racing team (managed by Florian Hebel) and those of its customers, who enter their Radicals, BMWs, MINIs and Porsches in championships like the MINI Challenge, Porsche Carrera Cup, Porsche Alpenpokal and the Porsche Sport Cup, which a-workx won in 2009.

All this experience—as well as plenty of practice preparing street/track cars for customers—was put to good use sharpening the M3 DCT’s claws to make it work on both road and track. If exquisite overall balance is the cornerstone of the M3’s repertoire, only a foolish tuner would upset it. Any power increase has to be matched by a chassis upgrade, and the brakes have to be up to the task of corralling the extra horses, as well.

In Euro spec, the standard M3 puts out 420 hp at 8,300 rpm and 295 lb-ft of torque at 3,900 rpm. Since a-workx is the official German importer for exhaust manufacturer Akrapovic, one of the Slovenian systems naturally took the place of this M3’s stock exhaust. The Akrapovic Evolution exhaust system for the M3 consists of flow-optimized link pipes with a pair of 100-cell metallic catalytic converters, integrated resonators and free-flowing rear silencers.

Made entirely from titanium, this system shaves a useful 50.6 lbs. and lowers backpressure by nearly 50%. Lowering back pressure is particularly useful for gaining power and torque in forced aspiration engines, but it can have a negative effect on naturally aspirated engines. In this case, it worked as intended, achieving the perfect balance of increased power and torque while giving the M3 a more sporting, bass-rich exhaust note.

Name:  aworxks1.jpg
Views: 7274
Size:  453.7 KB

Name:  aworxks2.jpg
Views: 4756
Size:  388.3 KB

On the dyno, the car shows an increase of 24 hp from 2,500 rpm upwards, along with an additional 25.8 lb-ft of torque throughout the rev range. The Akrapovic system also smooths out the dips and troughs in the factory power and torque curves, particularly between 3,500 and 6,500 rpm, and it required no additional ECU programming to achieve the desired effect. (The stock ECU adapts to the exhaust system’s lower backpressure automatically.)

While the a-workx M3’s 444 hp and 321 lb-ft might sound paltry compared with the numbers posted by the tuned C63 AMGs like the 575-hp Väth car mentioned earlier, power isn’t everything. In the case of the a-workx M3, its win over such powerhouses resulted instead from its 50/50 weight distribution, better suspension control and the ability to use almost all of its power more of the time. Another significant contributor to the car’s performance was the super-fast M-Double Clutch Transmission that saves around 1.5 seconds a lap over the manual at Hockenheim.

“The ‘box is absolutely superb on track, shifting like greased lightening,” said multiple Tuner GP winner and FIA GT Championship racer Wolfgang Kaufmann, who drove the car at Hockenheim. “Like a proper race car sequential gearbox, it takes away the distraction of a clutch and gearshift, enabling you to fully concentrate on your lap times.”

The manual may be more involving for the street driver, but there’s no getting away from the fact that not even a pro can approach DCT’s shifting times with a manual. DCT so convincingly chips away at lap times that the next question becomes how to get even more real world performance from your M3 without either compromising the integrity of its fabulous V8 or taking out a second mortgage on your house.

Lower and lighter

a-workx has one answer: KW coil-over suspension that’s adjustable for ride height plus compression and rebound damping. The coilovers were made to a-workx’ specifications, with settings calibrated by Kaufmann. The KW coilovers are paired with a-workx’ own solid suspension top mounts, which are stronger than standard and allow more negative camber to be dialed in for improved grip. Reducing the ride height—the car sits 30mm lower than a stock M3—also requires some recalibration of the geometry, and the mounts allow a-workx to adjust settings for camber and toe. Before sending the M3 onto the track at Hockenheim, the company also corner balanced the car with the driver on board.

All of that allows the a-workx M3 to get the most out of its tires, which for the Tuner GP were dry-weather, racing-compound Michelin Pilot Sport Cups. (Since the M3 comes with Michelin Pilot Sport Cup rubber as standard, the rules allowed a-workx to use a similar tire with a different compound.)

The Michelins measure 235/35ZR-19 front and 265/30ZR-19 rear, and they’re mounted on 8.5 and 10.0 x 19-inch OZ Racing Ultraleggera HLT alloys. Although they’re cast, these OZ wheels are practically as light as forged alloys in the same sizes. Weighing just at 20.9 and 22 lbs. each, front and rear, they save a total of 20.7 lbs. over the standard M3 wheels.

If BMW’s M cars have a weakness, it’s their brakes. Rather than go with an expensive big brake kit, a-workx addresses this with braided hoses and ceramic composite brake pads to better resist heat. These pads are perfect for track days, yet they don’t squeal in normal road use.

Though economical, the setup obviously works, as evidenced by the fact that the car won its class. Watching Kaufmann push the M3 right to the edge during his Tuner GP laps revealed a further impression, which is that the car looked totally lacking in drama even at the limit.

It looked consistent, as well. To win his class in the Tuner GP, Kaufmann had to post not the fastest single lap but the fastest average over five laps. Kaufmann’s 1:12.534 sec average lap and 1:12.201 second-fastest lap were not only enough to beat the more powerful Väth C63 AMG—which recorded a 1:13.056 average and a 1:12.801 best lap—they were also enough to put the a-workx M3 right up there with some of the slower turbocharged Porsches.

Name:  aworkx3.jpg
Views: 2933
Size:  318.4 KB

Crisp and quick

After Kaufmann proved the speed of the a-workx M3 on the track, it was down to me to see how well it would perform on public roads, and how suitable it would be as a daily driver. It’s certainly inconspicuous enough, with only its lower ride height, OZ Racing alloys and stripes to differentiate the a-workx car from any other white M3. And apart from its meatier, more bass-laden exhaust note, which leaves a better impression on both occupants and bystanders when it accelerates away, it starts up and drives around town like a standard car, too.

At low speeds, the ride on the KW coil-over suspension is barely firmer than stock. Thanks to a finely honed relationship between the uprated springs and dampers, it retains a good measure of comfort. The damping rates come into their own as the pace picks up, really smoothing out as speeds increase. And when you start to push hard on a twisty road, the suspension really impresses. Once you settle the car into a bend and start to lean on it, you can feel the coilovers’ rock-solid body control at work.

The combination of negative camber and sticky tires means that front-end grip is much improved, and the understeer normally experienced when using a bit too much throttle in a low gear in a tight bend is largely mitigated. This allows you to throttle up a bit earlier, and on track it makes for a higher exit speed from a bend and valuable fractions of a second against the stopwatch.

The different front-end geometry has also improved steering feel. Taking the original E30 M3 as a high point, each generation of M3 after that seems to have added a slight veil to the steering sensitivity. The a-workx suspension settings dial this back a generation, which is a good thing.

The modest negative camber dialed into the front end delivers a quicker turn-in, but there is no feeling of incipient oversteer as rear toe has been adjusted accordingly. If anything, both ends of the car track ’round resolutely until you near the limit, whereupon mild understeer gives way to a four-wheel drift followed by predictable oversteer.

The a-workx M3 has insane levels of mechanical grip, and its relative lack of torque compared to the 6.2-liter AMG also means that it’s harder to unhinge the rear end on good tarmac, especially as BMW’s clever electronic rear differential usually has more answers than a fixed-ratio mechanical diff. When it does let go, the slide is beautifully telegraphed, easy to catch and hold if you so wish. The stock M3 is a great drifter, but with less body roll and weight transfer, the a-workx car is even better.

It’s quick, too: Even though power hasn’t been increased substantially, our GPS-based Performance Box showed the a-workx M3 accelerating from zero to 62 mph in 4.4 seconds instead of 4.8 (as BMW claimed for a stock M3). It also scooted from 50 to 75 mph in 4.0 seconds in fourth gear rather than the 4.9 seconds recorded by BMW at the car’s introduction.

While the increase in power and torque is fairly modest in the overall scheme of things, the slightly crisper throttle response and even greater eagerness to chase down the redline is quite obvious. So, too, is the effect of increased grip and reduced unsprung weight on acceleration.

I have tested plenty of big-power supercharged M3s that are supercar killers in relatively plain clothing. But like supercars themselves, these cars are generally too fast for public roads. Even in Germany, going fast is becoming more difficult just through the sheer weight of traffic. With high speeds no longer a realistic goal, balance becomes ever more important.

Balance is one of the M3’s strong suits, and it’s critical that any modifications take place without disrupting BMW’s finely calibrated relationship between engine, chassis and brakes. The more familiar I became with the a-workx M3 DCT, the more it was apparent that this equilibrium had indeed been maintained. As a four-seat daily driver for sheer driving pleasure on both road and track, this crisp and well-balanced M3 hits the sweet spot.

Name:  aworkx4.jpg
Views: 4129
Size:  447.7 KB
Check on the Latest BMW News
Become a fan of Bimmerpost Facebook
Follow us on Bimmerpost Twitter
Subscribe to Bimmerpost Youtube Channel

Appreciate 0
      03-09-2010, 04:50 PM   #2
M3 Montreal

Drives: 2012 M3 SG ,DCT & 2011 S4
Join Date: Oct 2008
Location: Montreal , Canada

Posts: 2,185
iTrader: (0)

This is a great writeup and something anyone who tracks has come to learn... HP helps on the track but its the car thats quicker on the twisties that gets the faster lap times.
2012 E92-M3 Space Grey on Fox Red, DCT

2011 B8 S4 S-Tronic , Black on magma red
Appreciate 0
      03-09-2010, 06:21 PM   #3
Brigadier General

Drives: .
Join Date: Apr 2009
Location: .

Posts: 4,643
iTrader: (0)

Very informative and exciting read!
Appreciate 0
      03-09-2010, 06:33 PM   #4
Lieutenant Colonel

dimabimmer's Avatar
Drives: '11 E92 M3 ZCP 6MT
Join Date: Apr 2009
Location: Brooklyn to SoHo NYC

Posts: 1,748
iTrader: (0)

nice photos too. what kind of wheels are those?
'11 E92 M3 ZCP SG 6MT Tech Sound USB Heat Cloth Aluminium Sunshade
Appreciate 0
      03-09-2010, 06:40 PM   #5

Drives: jetblack e92 335i
Join Date: Apr 2006
Location: santa barbara & Los Angeles

Posts: 1,378
iTrader: (0)

Originally Posted by dimabimmer View Post
nice photos too. what kind of wheels are those?
yup...they look like a concave version of the cayenne GTS wheels and sportier...

i like a lott

Appreciate 0
      03-09-2010, 06:42 PM   #6

JayeJaymes's Avatar
Drives: AW 2011 ZCP M3
Join Date: Jul 2007
Location: So.Cal Moreno Valley

Posts: 1,133
iTrader: (7)

great find, wheels look interesting
Appreciate 0
      03-09-2010, 06:45 PM   #7
MBWorld Spy

Drives: M5, GT-R BE, C250
Join Date: Nov 2006
Location: Los Angeles

Posts: 588
iTrader: (1)

what wheels are those? they do look pretty awesome.
Appreciate 0
      03-09-2010, 06:47 PM   #8

Bimmerboy888's Avatar
Drives: E92 M3 DCT
Join Date: Nov 2009
Location: OC

Posts: 462
iTrader: (0)

Great article.
Appreciate 0
      03-09-2010, 06:55 PM   #9
Brigadier General

Drives: '08 E92 M3
Join Date: Jul 2008
Location: Los Angeles, Irvine

Posts: 4,268
iTrader: (4)

Garage List
2008 BMW E92 M3  [5.00]
Yup the wheels look good!
'08 E92 ///M3 - AW/BLK/CF, M-DCT, 19's
H&R, Vorsteiner, Eisenmann, BMC, BBS More to come...
Appreciate 0
      03-09-2010, 07:04 PM   #10
Private First Class

Drives: E92 M3
Join Date: Oct 2009
Location: Portugal

Posts: 148
iTrader: (0)

Garage List
2008 BMW M3  [3.20]
Wheels are OZ Superleggerra 8.5x19 front and 10x19 rear.
Appreciate 0
      03-09-2010, 07:21 PM   #11
Private First Class

Drives: e92 AW M3
Join Date: May 2009
Location: TX

Posts: 100
iTrader: (0)

19" Felgen OZ Ultraleggera

Appreciate 0
      03-09-2010, 07:23 PM   #12
Brigadier General

dlbrooks18's Avatar
Drives: e90 335i
Join Date: Nov 2008
Location: Los Angeles

Posts: 3,581
iTrader: (2)

Originally Posted by ee8 View Post
Wheels are OZ Superleggerra 8.5x19 front and 10x19 rear.
do you know what size tires?

2008 E90 335
Appreciate 0
      03-09-2010, 07:27 PM   #13
Private First Class

Drives: e92 AW M3
Join Date: May 2009
Location: TX

Posts: 100
iTrader: (0)

Originally Posted by dlbrooks18 View Post
do you know what size tires?

VA: 235/35 ZR19 87Y
HA: 265/30 ZR19 89Y
Appreciate 0
      03-09-2010, 07:32 PM   #14

Jack28's Avatar
Drives: E46 M3-E92 M3
Join Date: May 2006
Location: So/Ca Los Angeles

Posts: 1,319
iTrader: (0)

Send a message via AIM to Jack28
Originally Posted by M3 Montreal View Post
This is a great writeup and something anyone who tracks has come to learn... HP helps on the track but its the car thats quicker on the twisties that gets the faster lap times.

Could'nt agree with you more... Great writeup!!

E92 M3 ZCP- AW/FR w/Extended Leather) Packages: ZCP, 6MT, Fully Loaded
E46 M3 - AW/IR 6 Spd, Fully Loaded. 19'' BBS LM DBK, V-CSL C/F Bmpr, Botld, Diff, V-CSL Custum IR-CF Center Counsel, V-GTR Hood, Dixis Ti 76mm, Meisterschaft Ti Sec. 1&2, EvoSport Headers, CAI, D/A Chip, tck d/a, Alcantera Headliner with Imola Red Sttitching....
Appreciate 0
      03-09-2010, 08:38 PM   #15
Lieutenant Colonel

T89's Avatar
Drives: Z4 35i & Mini Cooper S
Join Date: Dec 2009
Location: Geneva & Joburg

Posts: 1,533
iTrader: (0)

Always good to see a Bmw do well, especially an ///M.
Thanks for sharing

Appreciate 0
      03-09-2010, 08:46 PM   #16
New Member

MaxSport's Avatar
Drives: BMW
Join Date: Mar 2010
Location: St.Paul MN.

Posts: 29
iTrader: (0)

Thanks for posting that!
Appreciate 0
      03-09-2010, 08:49 PM   #17
Lemon Jelly M3

Lemon Jelly M3's Avatar
Drives: M3 (E90,ZCP,6MT)
Join Date: Oct 2009
Location: East Coast

Posts: 478
iTrader: (0)

DCT is the way to go! Thanks for the post!
Appreciate 0
      03-09-2010, 09:05 PM   #18
Brigadier General

JoeyBananaz18's Avatar
Drives: metrocard
Join Date: May 2009
Location: Whitestone, NY

Posts: 3,763
iTrader: (3)

i feel like they tuned the car the way BMW builds the car. I mean that BMW has always been short on power when it came to M and AMG comparisons. And in almost all magazine tests, the BMW is chosen. the editors all know this, and they know the M3 is the more balanced car. For anyone who disagrees, watch the Toop Gear episode where they pitted the E92 M3 agains the C63 and the RS4. when it came to the C63 it was fishtailing everywhere. and when the RS4 had a similar lap time, they asked what all of the Merc's HP is doing. What they did here is take BMW's dynamics and engineering and bring it to the next level.
It's nothing most of already didn't know. thats why we have the ultimate driving machine. Very interesting read.
7/18/09- I pick up my baby- 2009 E92 335i Xdrive, Space Gray over Coral Red. Premium Pkg, Cold Weather Pkg, M-Sport Pkg, 193Ms, Gloss Black grills, Custom Gloss Black Mirrors, Performance shift and E-brake boot, M3 spoiler, Euro fog switch, gloss black interior tim, Coco-Mats (red/black), H&R coilovers, 19'' Alufelgen SF-71s......
Appreciate 0
      03-09-2010, 09:16 PM   #19
Lieutenant Colonel

Oulixes's Avatar
Drives: 330xi, 335i
Join Date: Feb 2009
Location: Terra Borealis

Posts: 1,941
iTrader: (0)

Outstanding report and photographs. The description of the titanium, low back pressure exhaust is so tempting, all I wish for is a sound file.
Appreciate 0
      03-10-2010, 12:42 AM   #20

PrimoM3's Avatar
Drives: '13 X5M
Join Date: Feb 2008
Location: West Coast, U.S.

Posts: 1,294
iTrader: (0)

Great article... thanks for sharing.

Someone send that first pic to Audi...
'13 Individual Frozen Brilliant White ///M3 Coupe
Ordered 2/15/12 | Euro Delivery on 9/21/12 | U.S. Redelivery on 12/6/12 | Motor Dead on 7/15/13

'13 Space Gray/Mugello Red X5///M
Pavement Punisher | Snow Muncher | Family and Board Hauler | Roadtripper
Appreciate 0
      03-10-2010, 01:53 AM   #21
Brigadier General

e46e92love's Avatar
Drives: e92 ///M3; X3 (wife's)
Join Date: Nov 2007
Location: The East Side of Things

Posts: 3,054
iTrader: (0)

Send a message via AIM to e46e92love
Its these type of articles that makes me scratch my head when you hear rumors of //M changing their philosophy to low-rev, forced induction, torque and horsepower monsters........just don't get it


"'s not about the money and not about the brand of the car, it's about handling,performance and passion......And that, no other car has all together like an M3........when you talk about the most complete car the M is invincible." --Tony Kanaan.
Appreciate 0
      03-10-2010, 02:01 AM   #22
Lieutenant General

swamp2's Avatar
Drives: E92 M3
Join Date: Sep 2006
Location: San Diego, CA USA

Posts: 10,201
iTrader: (1)

Glad I finally saw the link. I was going to say what a crappy article as the text said nothing about the suspension and adjustments. Obviously after all the praise I knew I better have another look.

The authors got it completely wrong though about the M3 differential it is not an electronic diff, it is fully mechanical. It is the GKN Viscodrive system.

The praise for the over achieving car also leaves out one very key ingredient - the driver!
Appreciate 0
Post Reply


Thread Tools Search this Thread
Search this Thread:

Advanced Search

Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off

All times are GMT -5. The time now is 11:55 AM.

Powered by vBulletin® Version 3.7.0
Copyright ©2000 - 2014, Jelsoft Enterprises Ltd.,,,,,,,,, logo and trademark are properties of BIMMERPOST